Home / Insight / New Generation of Miners Embracing Renewable Energy Technologies

New Generation of Miners Embracing Renewable Energy Technologies

Renewable Energy Technologies

Until quite recently, miners generally used words like ‘unreliable’, ‘expensive’, and ‘risky’ to describe renewable-energy power. But, outdated perceptions of most forms of renewable power are slowly giving way to a new generation of miners. In fact, they are embracing new renewable energy technologies. Consulting engineering firm Hatch former director of solar and wind, Rob Lydan, participated at the Renewable Energy and Mining Summit, held in Toronto last week. He said that the fact remained that renewable energy was cheaper than fossil fuel power solutions, such as diesel-fired generators.

Are hybrid renewables the solution?

Today, miners typically spend about 30% of the operating cost of a mine on energy. That is in comparison with 23% to 25% a few years ago. And, at some point, mining firms cannot be profitable unless they decrease the cost of energy. Lydan pointed out that operating a typical diesel-powered generation set would cost about $0.28/kWh to $0.32/kWh, compared with the current average operating cost of solar power of about $0.17/kWh and wind power of about $0.14/kWh.

However, owing to the supply of renewable energy technologies being inherently intermittent, except for geothermal power plants capable of maintaining baseload requirements at the low end of the cost curve, a more advantageous approach for miners would be to engineer hybrid renewables solutions. They will increase the installation’s reliability, while, at the same time, achieve operating cost savings of 10% to 30%.

Lydan said the balance between diesel and renewable power had tipped owing to the price of both solar and wind energy has declined significantly. In fact, the cost of solar energy components had fallen by nearly two-thirds in the past three years, he said. Miners like the concept of green energy for a number of reasons. They prefer it because it helps new projects gain a social license, it leaves a positive legacy after the mine closes. And, it gives companies the potential to earn carbon credits. But, he stressed, miners, need the promise of cost reductions before making a move.

What is the future of renewable energy technologies?

“At this point, hybrid energy projects have to compete against all the capital demands of the mine. And they have to have a payback similar to any capital activity at the mine. “Renewable power project performance is so well understood these days that risk premiums associated with their adoption in utility markets are lower than the risk premium in mining projects,” Lydan said, adding that investors were in fact keener to invest in a new renewable-energy project than in a new mining project in the current economic climate. Renewables solutions for mines make the most sense for projects in remote locations, especially for off-grid projects.

Lydan pointed out that component costs did not determine the type of renewable energy a mine should implement. But, rather what natural resources were available. Size mattered too; Lydan explained that solar projects were easier to install for small energy requirements. That is because cranes and other heavy equipment are not necessary. Of all the issues resources firms needed to consider around implementing a renewable solution, integration remained the top issue. “Miners won’t accept a situation where you’re going to shut down their mine. They’re not interested in that. Therefore, everything from the question of backup energy sources to protecting the power system at a mine needs to be carefully considered,” he said.

Related Insight

Glint and Glare Study

FAA Glint and Glare Study-Airport Solar

Here is the Preliminary Design for 15.5MW Alberta Solar Project. It includes Preliminary layout, equipment selection, energy production analysis. And, most importantly, glint and glare study for the 15MWac project in Alberta, Canada. In July of 2019, The client contracted Phoventus Inc to perform a glint and glare assessment for the proposed solar layout. This assessment uses GlareGauge. That’s a […]

Read more
Minerals and Metals

The Growing Role of Minerals and Metals for a Low Carbon Future

“The Growing Role of Minerals and Metals for a Low Carbon Future.” There is growing awareness that human activities are having a major impact on the earth’s ecosphere. So much so that many are now defining a new geological era: the Anthropocene. That is a time when humans have become the driving force in the earth’s physical […]

Read more
Phoventus

Phoventus Celebrates a Decade of Positive Growth

Phoventus celebrates a decade of positive growth for renewables and hybrid power solutions As Phoventus celebrates its 10th Anniversary, we look back at the extraordinary rise in the use of renewable energy worldwide since we launched our business and ponder the challenges for the sector that lay ahead. It’s quite extraordinary to reflect back on […]

Read more